Institute of Chemistry and Chemical Technology SB RAS, Federal Research Center “Krasnoyarsk Science Center SB RAS”, Krasnoyarsk, Russia:
I. Yu. Fleitlikh, Lead Researcher, Сandidate of Сhemical Sciences
N. A. Grigorieva, Senior Researcher, Сandidate of Сhemical Sciences, e-mail: natasha@icct.ru

Indium (III) extraction with poly(2-ethylhexyl)phosphonitrile acid (P2EHPNA, HX), di-(2-ethylhexyl)phosphoric acid (D2EHPA), as well as their mixtures with trialkylbenzylammonium chloride (TABAC) from sulfuric acid and zinc sulfate solutions in kerosene was studied. It has been shown that in a wide range of acidity (0.5–2.5 M H₂SO₄), the extraction capacity of P2EHPNA is much higher than that of D2EHPA. A significant increase in the extraction ability is explained by the absence of cyclic dimerization, characteristic of D2EHPA. Indium extraction decreases with an increase in the acidity of the aqueous solution. It was assumed that indium is extracted into the organic phase by a cation exchange mechanism with the formation of complexes InX₃(HX)_3n–3 and InX₃(HX)_2n–3, where HX is the monomer group of the extractant, and n = 2÷4. The introduction of TABAC into the organic phase containing P2EHPNA and D2EHPA leads to a strong decrease in the extraction ability of the reagents. The isotherm with 0.3 mol/dm3 of P2EHFNA in kerosene has a steep character. This makes it possible to extract almost completely (> 99%) in 1–2 steps with indium content of 0.5 g/dm³ in the initial solution. Since the stripping of In with mineral acids from P2EHPNA is impossible, its stripping was carried out with alkaline solutions of a complexing agent (polyhydric alcohol – sorbitol). It was shown that the degree of stripping with sorbitol solutions (2.0 M NaOH + 2.0 M sorbitol) is about 100% already in 3 minutes of phase contact. It has also been shown that when P2EHPNA in kerosene is used, not only almost complete strippig of indium with sorbitol solutions takes place, but also its noticeable concentration in re-extracts in one step (~ 35 g/dm³). At the same time, the phase separation was fast and high quality. It is obvious that the extraction systems with P2EHPNA is of interest for indium extraction from various technological solutions.

This work was conducted within the framework of the budget project 0287-2021-0014 for Institute of Chemistry and Chemical Technology SB RAS using the equipment of Krasnoyarsk Regional Research Equipment Centre of SB RAS.

1. Fedorov P. I., Akchurin R. Kh. Indium. Moscow : Nauka; MAIK “Nauka / Interperiodica”. 2000. p. 276.
2. Virolainen S., Ibana D., Paatero E. Recovery of indium from indium tin oxide by solvent extraction. Hydrometallurgy. 2011. Vol. 107, Iss. 1-2. pp. 56–61.
3. Yen F., Chang T. C., Laohaprapanon S., Chen L. Recovery of Indium from LCD Waste by Solvent Extraction and the Supported Liquid Membrane with Strip Dispersion Using D2EHPA as the Extractant. Solvent Extraction Research and Solvent Extraction Research and Development Japan. 2016. Vol. 23, Iss. 1. pp. 63–73.
4. Li X., Deng Z., Wei C., Li M., Fan C., Rong H. Direct solvent extraction of indium from a zinc residue reductive leach solution by D2EHPA. Hydrometallurgy. 2015. Vol. 156. pp. 1–5.
5. Le T., Xiao B., Ju S., Peng J., Jiang F. Separation of indium from impurities in T-type microreactor with D2EHPA. Hydrometallurgy. 2019. Vol. 183. pp. 79–86.
6. Timofeev K. L., Maltsev G. I., Usoltsev A. V., Naboychenko S. S. Sorption technology for extracting indium from solutions of zinc production. Izvestiya vuzov. Tsvetnaya metallurgiya. 2017. Vol. 2. pp. 43–50.
7. Lupi C., Pilone D. In (III) hydrometallurgical recovery from secondary materials by solvent extraction. Journal of Environmental Chemical Engineering. 2014. Vol. 2, Iss. 1. pp. 100–104.
8. Rodriguez A., Gote G., Bauer D. Recovery of indium (3+) from mixed hydrocyloric acid – sulphuric acid by solvent extraction with Cyanex 301. Solvent Extraction and Ion Exchange. 1992. Vol. 10, Iss. 5. pp. 811–827.
9. Chou W. S., Shen Y. H., Yang S. J., Hsiao T. C., Huang L. F. Recovery of indium from the etching solution of indium tin oxide by solvent extraction. Environmental Progress Sustainable Energy. 2016. Vol. 35, Iss. 3. pp. 758–763
10. Kazanbaev L. A., Pashkov G. L., Kulmukhamedov G. K., Fleitlikh I. Yu., Kozlov A. P. et al. Extraction of indium from sulfate solutions by mixtures of di(2-ethylhexyl)phosphoric and monocarboxylic acids. Izvestiya vuzov. Tsvetnaya metallurgiya. 2002. Vol. 4, pp.15–20.
11. Pashkov G. L., Mikhnev A. D., Kolmakova L. P., Kulenova N. A. Extraction of indium from sulfate solutions with a mixture of di(2-ethylhexyl) phosphoric acid and trialkylamine. Abstracts of the IX All-Union Conference on Extraction. 1991. Adler. p. 427.
12. Nguyen T. H., Lee M. S. A Review on Separation of Gallium and Indium from Leach Liquors by Solvent Extraction and Ion Exchange. Mineral Processing and Extractive Metallurgy. 2019. Vol. 40, Iss. 4. pp. 278–291
13. Rosen A. M., Volk V. I., Nikolotova Z. I., Kartasheva N. A. Extraction of europium from nitric acid solutions with poly(2-ethylhexyl)phosphonitrile acid (P2EHNPA). Zhurnal neorganicheskoy khimii. 1982. Vol. 27, Iss. 2. pp.431–435.
14. Rosen A. M., Volk V. I., Zakharkin B. S., Kartasheva N. A., Nikolotova Z. I. Extractants for deep extraction of TPE from wastes of radiochemical processes. Radiokhimiya. 1999. Vol. 41, Iss. 3. pp. 205–211.
15. Pyatnitskiy I. V., Klibus A. Kh. Masking effect of some fatty polyhydric alcohols on metal precipitation reactions. Ukrainskiy khimichesky zhurnal. 1963. Vol. 29, Iss. 3. pp. 245–251.
16. Albert A., Sergent E. Ionization constants of acids and bases. Moscow : Khimiya. 1964. 380 p.
17. TU 95.104–86. Poly(2-ethylhexyl)phosphonitrile acid. Introduced: 12.05.1986.
18. TU 38.401-58-8–90. Kerosene for technical purposes. Introduced: 01.01.1991.
19. TU9197-008-72315488–2010. Food sorbitol packaged. Introduced: 12.03.2010.
20. Ishankhodjaev S. The use of polyatomic alcohols in the hydrometallurgy of non-ferrous metals. Scientific and technical progress in the development of cities in Uzbekistan. Navoi, 1979. pp. 153–154.
21. 234. Ponomareva E. I., Zagorodnyaya A. N., Abisheva Z. S. Separation of indium from iron and tin at the stage of stripping. Abstracts of XI Russian conference on extraction. 1998. Moscow. P. 234.
22. Akimova I. D., Chumakova G. L., Molchanova T. V., Golovko V. V. Obtaining scandium concentrate by liquid extraction from hydrolytic sulfuric acid effluents of titanium dioxide production. Tsvetnye Metally. 2017. Vol. 3. pp. 63–68. DOI: 10.17580/tsm.2017.03.10.