Журналы →  Gornyi Zhurnal →  2022 →  №4 →  Назад

Название Reliability of dump trucks in placer mining in permafrost zone
DOI 10.17580/gzh.2022.04.15
Автор Bochkarev Yu. S., Zyryanov I. V.
Информация об авторе

Ammosov North-Eastern Federal University, Yakutsk, Russia:

Yu. S. Bochkarev, Associate Professor


Mirny Polytechnic Institute (Branch), Ammosov North-Eastern Federal University, Mirny, Russia:

I. V. Zyryanov, Head of Department, Professor, Doctor of Engineering Sciences, ZyryanovIV@alrosa.ru


This study analyzes failures of dump trucks in open pit mines depending on the season and dump truck service life during placer mining in the permafrost zone. It i s found that more than half of failures are the faults of suspension, engine and drive axle. It is determined that the number of failures of dump trucks increases in the warm season (May–Sep tember) and with extension of service life of dump trucks more than by 1.5–2.0 times. The yearly increase in the number of failures is due to the deterioration of road conditions in the warm season. Melting p ermafrost causes an almost semiliquid mixture of water and various types of soil and sand in the work zone. The load-bearing capacity of soilwo rsens. The wheels of moving dump trucks make deeper track on th e road surface. This results in the increased loads imposed on the components and assemblies of the chassis, transmission and hydraulic system. The chassis components and parts, which have no closed (isolated) lubrication system, are subje cted to abrasive wear because of dirt getting into them. The data on the dump truck failures per the components and aggregates, as well as on the number of failures subject to the season and dump truck service life are obtained. Th e implemented studies into reliability of dump trucks in placer mining in the permafrost zone allow recommending balancing the seasonal variation in the number of failures by production scheduling with regard to the 75 % increase in the maintenance efforts in the warm season. For achieving efficiency and rhythmicity of placer mining operations in the warm season, it is necessary to take into account deterioration of road conditions, which affects the working capacity of dump trucks.

Ключевые слова Dump truck, placers, reliability, reliability, number of failures, seasonality, service life, road conditions
Библиографический список

1. Seifoori S., Parrany A. M., Khodayari M. A high-cycle fatigue failure analysis for the t urbocharger shaft of BELAZ 75131 mining dump truck. Engineering Failure Analysis. 2020. Vol. 116. 104752. DOI: 10.1016/j.engfailanal.2020.104752
2. Zhetesova G. S., Dandybaev E. S., Zhunuspekov D. S., Zhekibaeva K. K. Improvement of the Organization of Maintenance and Repair of Dump-Cars. Material and Mechanical Engineering Technology. 2020. Vol. 1, No 1. pp. 33–38.
3. Stenin D. V., Stenina N. A., Bakanov A. A. Evaluation of the Open Pit Vehicles Loading Influence on the Reliability of Motor – Wheel Reducers. Coal in the 21st Century: Mining, Processing and Safety : Proceedings of the 8th Russian-Chinese Symposium. Amsterdam : Atlantis Press, 2016. pp. 256–259.
4. Sładkowski A. V., Utegenova A. E., Kolga A. D., Gavrishev S. E., Stolpovskikh I. N. et al. Improving the efficiency of using dump trucks under conditions of career at open mining works. Nauchnyi vestnik Natsionalnogo gornogo universiteta. 2019. No. 2. pp. 36–42.

5. Dyson G. Exploring Factors that Affect Reliability of Open Pit Heavy Mining Dump Trucks: A Case of Bisha Mining Share Company, Eritrea. International Journal of Science and Research. 2020. Vol. 9, Iss. 6. pp. 206–219.
6. Kuzin E. G., Pudov E. Yu., Dubinkin D. M. Analysis of failures of mining dump truck components under operating conditions. Gornoe oborudovanie i elektromekhanika. 2021. No. 2(154). pp. 55–61.
7. Anitsratov K. Yu. (Ed.). Open pit mining – The 21st century. Reference book. Moscow : Sistema maksimum, 2019. Vol. 1. 640 p.
8. Dadonov M. V., Sobolenko M. A. Nature of cracking in frames of BelAZ-7555 dump trucks in operating conditions of Salek JSC, Kiselevsk. Russia the Young : Proceeding of XIII All-Russian Conference with International Participation. Kemerovo : Kuzbasskiy gosudarstvennyi tekhnicheskiy universitet imeni T. F. Gorbacheva, 2021.
9. Brilkov M. N., Lomov A. A., Danchenko I. A. Effect of operational parameters on technical state of dump trucks in open pit mines. Russia the Young : Proceeding of XIII All-Russian Conference with International Participation. Kemerovo : Kuzbasskiy gosudarstvennyi tekhnicheskiy universitet imeni T. F. Gorbacheva, 2021.
10. Zhuravlev A. G. The issues of optimization parameters of quarry transport systems. GIAB. 2020. No. 3-1. pp. 583–601.
11. Zakharov N. S., Akzhol A., Tenkovskaya S. A. Factors affecting the reliability of tip trucks working in the conditions of Western Siberia. Transportnoe delo Rossii. 2018. No. 4. pp. 130–132.
12. Gryaznov M. V., Antropova E. M., Balikova E. A. Reduction in cost of maintenance and repair of dump trucks in open pit mines. Theory and Practice of Trucking and Transport Logistics : Transactions of the Transport Management and Control Department in the framework of the International Conference. Omsk : SibADI, 2016. pp. 36–41.
13. Klebanov A. F., Sizemov D. N., Kadochnikov M. V. Integrated Approach to Remote Monitoring of Technical and Operating Conditions of Mine Dump Trucks. Gornaya promyshlennost. 2020. No. 2. pp. 75–81.
14. Machulov V. N. Control of mining-and-haulage systems. Gornaya promyshlennost. 2013. No. 6. p. 88.
15. Bochkarev Yu. S., Vikulov M. A., Ishkov A. M., Sedalishchev I. I. Research of the exploitation of dump trucks BelAZ-7540 in conditions of the North. GIAB. 2015. No. 7. pp. 151–157.
16. Ishkov A. M. Mathematical rythmology in working efficiency of machinery in the North. Yakutsk : Izdatelstvo YaNTs SO RAN, 2000. 319 p.
17. Khabibullin R. G., Makarova I. V., Mukhametdinov E. M. Effect of the seasonality factor the technical state of vehicles. Advanced Technologies in Transport Systems : Proceedings of VII Russian Conference. Orenburg : Orenburgskiy gosudarstvennyi universitet, 2005. pp. 320–327.
18. Zakharov N. S., Abakumov G. V., Voznesenskiy A. V. Seasonal effects on use of resources in operation of vehicles. Tyumen : TyumGNGU, 2011. 115 p.
19. Dovbnya B. E., Zakharov N. S. Seasonal effects on industrial scheduling of maintenance of vehicles. Problems of Operation of Cars, and Construction, Road-Making and Hoisting and Transport Machines : Inter-University Collection of Papers. Tyumen : Tyumenskiy gosudarstvennyi neftegazovyi universitet, 2001. pp. 18–25.
20. Zakharov N. S., Rakitin A. N., Orlov S. M. Seasonal effects on reliability and spare capacity of vehicles. Operation of Transport Systems under Severe Conditions : International Conference Proceedings. Tyumen : Tyumenskiy industrialnyi universitet, 2002. pp. 113–115.
21. Desherevskii A. V., Zhuravlev V. I., Nikolsky A. N., Sidorin A. Ya. Problems in Analyzing Time Series with Gaps and Their Solution with the WinABD Software Package. Izvestiya. Atmospheric and Oceanic Physics. 2016. Vol. 53, No. 7. pp. 659–678.

Language of full-text русский
Полный текст статьи Получить